Honda GL500 Silver Wing Interstate
It could reach a top speed of 175.4 km/h / 109 mph.
Honda GL500 Silver Wing Interstate | |
Manufacturer | |
---|---|
Production | 1981-82 |
Class | Tourer |
Engine | Four-stroke. longitudinal 800 V-twin, SOHC 4 valves per cylinder operated by pushrods |
Compression ratio | 10.0:1 |
Top Speed | 175.4 km/h / 109 mph |
Ignition | Transistor |
Transmission | 5 Speed |
Suspension | Front: Telescopic coil spring air assisted Rear: Swing arm compound linkage to single shock |
Brakes | Front: 2 x 240mm discs, 2 piston calipers Rear: Drum |
Front Tire | 2.15-19 |
Rear Tire | 130/90-16 |
Weight | 240 kg / 529 lbs (wet) |
Recommended Oil | Honda GN4 10W-40 |
Fuel Capacity | 17.5 L / 4.62 US gal |
Manuals | Service Manual |
EngineEdit
The engine was a Liquid cooled cooled Four-stroke. longitudinal 800 V-twin, SOHC 4 valves per cylinder operated by pushrods. The engine featured a 10.0:1 compression ratio.
ChassisEdit
It came with a 2.15-19 front tire and a 130/90-16 rear tire. Stopping was achieved via 2 x 240mm discs, 2 piston calipers in the front and a Drum in the rear. The front suspension was a Telescopic coil spring air assisted while the rear was equipped with a Swing arm compound linkage to single shock. The GL500 Silver Wing Interstate was fitted with a 17.5 L / 4.62 US gal fuel tank.
PhotosEdit
OverviewEdit
Honda GL 500 Silver Wing Interstate
Much thought went into the design of Honda's 500-class full-dress tourer. The
existing CX500 V-twin engine would obviously be the ideal choice as power plant,
but what about the chassis? One faction of Honda development guys thought the
best approach was to take the standard CXengine, chassis and all and simply
bolt on a fairing and some saddlebags. Another group wanted to see the pushrod
V-twin powering an all-new chassis one designed from the ground up for touring
use with a fairing and bags, something with more advanced engineering and clean,
integrated styling.
Luckily for the middleweight touring rider, Honda finally settled on the
latter approach. What they came up with has been dubbed the GL500I Silver Wing
Interstate, essentially a smaller version of the GL1100 Interstate introduced
last year. Since both machines are fitted with the same injection-molded plastic
fairing, the similarities in the styling of the two bikes are striking. No other
pieces interchange, however; the GL500 is built entirely as a 500-class machine.
The GL500 is available two ways: fully dressed and ready for open-road work,
or stripped-down without the fairing and saddlebags (the version we tested in
our June middleweight comparison). The only mechanical difference between the
two machines is in the front brake. The Interstate has dual discs and Honda's
twin-piston calipers, while the stripped-down GL has one larger diameter disc
and a single twin-piston caliper. In virtually all other respects, the two GLs
are identical.
The four-valve twin that powers the Interstate is pretty much the same unit
that has seen action in the CX500 for the past few years. The only differences
are a change from magneto CDI to transistorized ignition and longer intake
manifolds to provide a more inboard carburetor location. The little
plain-bearing V-twin is a willing revver redline is 9700 rpm. Low (high
numerically) gearing has the GL spinning a brisk 5395 rpm at 60 mph in top gear,
but the 80-degree V engine layout keeps vibration comfortably low. Engine and
drive-line maintenance are simple on the GL, since the water-cooled engine is
equipped with easy-to-service, threaded valve adjusters and low-maintenance
shaft final drive. There's enough horsepower on hand to push the Interstate
through the quarter-mile in 14.94 seconds at 86.04 mphor about a second slower
than the unfaired GL. The Interstate's roll-on terminal speed after 200 yards
from 50 mph in top gear is 67.6 mphonly two mph slower than the GL's. The
Interstate isn't particularly big on mid-range power, but it is carbureted
cleanly and builds its power predictably as the revs rise. The GL can easily
work up enough speed to exceed the national limit when fully loaded, but steep
hills and high altitudes often require a downshift or two and plenty of revving.
High engine speeds send a healthy buzz through the pegs and drop the fuel
mileage considerably. Our test bike occasionally turned in tankfuls that ran in
the low 30s when pushing strong headwinds and climbing steep hills.
Since it employs the same gearbox and clutch as has been used in the CX500 since its introduction, the GL can be a balky shifter. Upshifts must be executed deliberately to prevent occasional missed shifts. During drag-strip-type speed shifts the GL's clutch slips. Luckily, this type of shifting abuse isn't standard fare for touring riders. The clutch has its good points during normal use. The lever pull is light and the engagement smooth and predictable. The four-valve engine is an excellent basis for a middleweight dresser, but just as important is its chassis. It is entirely new, and incorporates a number of features to make it a better touring platform. The GL's wheelbase is longer than the CX500's, and the steering geometry is slower to provide more stability. Even with these changes, the Interstate steers lightly and easily. There's also a bit more suspension travel at each end to better handle bumps and potholes. Suspension-wise, the GL has a lot more on the CX than just travel. Instead of the CX's conventional dual-shock rear suspension, the GL has Honda's Pro-Link system. A single shock is mounted vertically between the swingarm and engine, and is connected to the swing-arm with a linkage. This linkage delivers rising-rate suspension geometry, meaning that the farther the suspension compresses, the more the shock's leverage deficit is reduced. This progressivity keeps the suspension soft and responsive to small bumps, while allowing it to become stiffer to handle big bumps. The Showa damper has fixed damping and a straight-rate coil spring. An adjustable air spring built into the shock lets you fine-tune the suspension action to suit load and riding conditions. The pressure can be set anywhere between zero and 70 psi, so there's plenty of room for adjustment. The Pro-Link makes the GL the smoothest-riding middleweight on the highway. The rear suspension is very responsive to small lips and seams in the pavement. There's little of the usual spine-pounding on those cursed freeway expansion joints, so long hours on the super-slab seem to pass more quickly. Thanks to the progressive geometry and air springing, the Pro-Link eats up the big bumps too. With the air pressure adjusted to cope with the rider and cargo weight, bottoming isn't noticeable. The only drawback to the system is the shock's marginal rebound damping. The light damping undoubtedly contributes to the excellent responsiveness on small bumps, but it isn't sufficient to keep things under control when the shock rebounds after a big impact. The back end of the Honda pogos somewhat on bumpy roads, occasionally badly enough to bounce the rider up off the seat during fast riding. The same damping insufficiency contributes to a chassis instability on high-speed corners. The Interstate isn't the appropriate tool to use to hone your road-racing skills, and isn't intended to be. However, a bit more rebound damping would improve the bike's handling under almost all conditions, while only sacrificing a tiny portion of its butter-smooth ride on the highway. We experienced the same damping shortage on the standard GL, too. The front fork nearly matches the responsiveness of the Pro-Link, but delivers far more wheel control. The air/ spring fork's stanchion tubes can be inflated at a common filler, so adjustments are simple. Honda's dual syntallic bushings cut down on stiction to make the fork more responsive to sharp lips and jolts. The 35mm Showa fork never bottoms noticeably, even during hard braking on large bumps, provided the air pressure is jacked up sufficiently in advance. Honda didn't cut corners in the braking department either. Up front, a pair of discs are gripped by powerful, dual piston calipers. A two-fingered squeeze on the lever will bring the front brake to the point of lock-up, and the feel is excellent. In the rear, the single-leading-shoe drum-type brake is adequate. Though the chassis bits are all pretty decent stuff, they're outshone by the slick touring gear. The large fairing has an adjustable windscreen and pro vides excellent protection. Even tall riders easily fit within the pocket of calm air created by the fairing. The fairing-mounted mirrors vibrate somewhat and are positioned far away from the rider, so the images are small and blurred at certain engine speeds. Small adjustable vents built into the fairing are intended to let fresh air in behind the fairing if desired, but they are too small to be effective. Honda offers an optional AM/FM radio, a clock and a voltmeter to mount in the fairing dash. Though the upper-body wind protection is excellent, the abbreviated fairing-lowers leave your lower legs in the wind. On hot days, this is a blessing, since hot air from the engine's radiator fills the calm air envelope and makes the rider uncomfortably hot. Of course, on cold rides this heat keeps the rest of your body warm while your legs are chilled. Two compartments in the fairing provide storage space and can handle five pounds each. The one on the left has a snap-down vinyl cover; the right one's plastic lid locks with the ignition key. The Interstate comes equipped with a decent, though not remarkably good, solo saddle and storage trunk. If you wish to carry a passenger, the trunk must be unbolted and replaced with the passenger seat included with the bike. The lockable trunk can handle 20 pounds worth of gear, and is much larger than the compact trunk that comes standard on the stripped-down, unfaired GL500. The smaller trunk can be purchased separately as an accessory. The saddlebags are nicely finished, detachable units that lock shut and in place on the bike. They feature sturdy aluminum frames with rubber gaskets to keep water out and internal elastic straps that make it easy to secure the contents. Honda suggests that each bag be loaded with no more than 20 pounds worth of cargo. The bags are deeper than those on the CBX, so they hold considerably more. Our only complaint is with the overly complicated mounting system that uses several latching mechanisms, including seat belt-type buckles and locking arms. The bag-mounting mechanisms on the CBX are much simpler, and they don't pinch your fingers. Like all the locks on the bike, the bags' locks are operated by the ignition key. At least for the moment, Honda's GL500 Interstate is literally in a class by itself. No other manufacturer currently offers a ready-to-ride, full-dress middleweight tourer, so the only alternative to the Honda is to do it yourself. If you go that route, it's unlikely that you'll come up with anything that will match the integration, fit and excellent finish of the Silver Wing Interstate.
Source Motorcyclist 1981
Make Model | Honda GL 500 Silver Wing Interstate |
---|---|
Year | 1981-82 |
Engine Type | Four-stroke. longitudinal 800 V-twin, SOHC 4 valves per cylinder operated by pushrods |
Displacement | 496.8 cc / 30.3 cub in. |
Bore X Stroke | 78 x 52 mm |
Compression | 10.0:1 |
Cooling System | Liquid cooled |
Induction | 2 x 34mm Keihin carbs. |
Ignition | Transistor |
Starting | Electric |
Max Power | 37.3 kW / 50 hp @ 9000 rpm |
Max Torque | 46 Nm / 4.69 kgf-m / 33.9 lb-ft @ 7000 rpm |
Transmission | 5 Speed |
Final Drive | Shaft |
Front Suspension | Telescopic coil spring air assisted |
Rear Suspension | Swing arm compound linkage to single shock |
Front Brakes | 2 x 240mm discs, 2 piston calipers |
Rear Brakes | Drum |
Front Tire | 2.15-19 |
Rear Tire | 130/90-16 |
Wet Weight | 240 kg / 529 lbs |
Fuel Capacity | 17.5 L / 4.62 US gal |
Reserve | 2.6L / 0.69 US gal |
Consumption Average | 5.1 L/100 km / 19.7 km/l / 46.3 mpg |
Braking 100 Km/h - 0 | 44.2 m / 145 ft |
Standing ¼ Mile | 15.0 sec / 134.2 km/h / 83.4 mph |
Top Speed | 175.4 km/h / 109 mph |